某含锌烟尘中性—酸性两段浸出试验

金属矿山 ›› 2013, Vol. 42 ›› Issue (02): 164-167.

• 综合利用 • 上一篇

某含锌烟尘中性—酸性两段浸出试验

李岩^1,2，杨丽梅^1,2，徐政^1,2，徐瑞^1,2，王巍^1,2

1.北京有色金属研究总院；2.生物冶金国家工程实验室

出版日期:2013-02-15 发布日期:2013-03-13
基金资助:
* “十二五”国家科技支撑计划项目（编号：2011BAE23B00）。

Study about Two-stage Neutral-acid Leaching Process on A Zinc-borne Dust

Li Yan^1,2，Yang Limei^1,2，Xu Zheng^1,2，Xu Rui^1,2，Wang Wei^1,2

1.General Research Institute for Nonferrous Metals；2.National Engineering Laboratory of Biohydrometallurgy

Online:2013-02-15 Published:2013-03-13

摘要/Abstract

摘要： 为回收某废镀锌板炼钢烟尘中以氧化锌为主的锌，对其进行了中性—酸性两段浸出试验。首先通过条件试验确定了中性浸出时的适宜工艺参数为始酸浓度0 g/L、液固比9 mL/g、搅拌强度200 r/min、浸出温度25 ℃、浸出时间80 min，酸性浸出时的适宜工艺参数为始酸浓度20 g/L、液固比9 mL/g、搅拌强度500 r/min、浸出温度25 ℃、浸出时间80 min，然后按所确定的工艺参数进行中性浸出液为产出液、酸性浸出液返回中性浸出作业的闭路流程试验，试验稳定后锌的浸出率达到90.36%，浸出液中锌的含量为10.14 g/L，铁含量仅为0.56 g/L。

关键词: 废镀锌钢板, 含锌烟尘, 中性—酸性两段浸出, 浸出终点pH

Abstract: In order to recycle zinc from zinc oxide of the waste galvanized sheet zinc-borne dust, two-stage neutral-acid continuous leaching process was conducted. Through the conditional tests, the optimal technical parameters for the neutral leaching were determined as the initial acid concentration 0 g/L, the ratio of liquid to solid 9 mL/g, stirring intensity of 200 r/min, the leaching temperature of 25 ℃ for 80 min, for the acid leaching as the starting acid concentration of 20 g/L, the ratio of liquid to solid 9 mL/g, stirring intensity of 500 r/min, the leaching temperature of 25 ℃ for 80 min. Then under the technical parameters above, a closed-circuit test was made by using the neutral leaching solution as output solution, and the acid leaching return to the neutral leaching solution. In the tests, Zn leaching rate reaches 90.36%. Zn content in leaching solution is 10.14 g/L, and iron content is 0.56 g/L only.

Key words: Waste galvanized sheet, Zinc-borne dust, Neutral-acid two-stage leaching, Final leaching pH

李岩, 杨丽梅, 徐政, 徐瑞, 王巍. 某含锌烟尘中性—酸性两段浸出试验[J]. 金属矿山, 2013, 42(02): 164-167.

LI Yan, YANG Li-Mei, XU Zheng, XU Rui, WANG Wei. Study about Two-stage Neutral-acid Leaching Process on A Zinc-borne Dust[J]. Metal Mine, 2013, 42(02): 164-167.

扫码分享

某含锌烟尘中性—酸性两段浸出试验

Study about Two-stage Neutral-acid Leaching Process on A Zinc-borne Dust

PDF (PC)

可视化

摘要/Abstract

引用本文

使用本文

参考文献

相关文章 0

编辑推荐

Metrics

本文评价