尾矿动态浓密过程中底流浓度主要影响因素研究

金属矿山 ›› 2016, Vol. 45 ›› Issue (11): 102-105.

尾矿动态浓密过程中底流浓度主要影响因素研究

高维鸿¹，王洪江^1,2，陈辉³，杨柳华¹，张磊¹

1.北京科技大学土木与环境工程学院，北京100083；2.金属矿山高效开采与安全教育部重点实验室，北京100083；3.中国黄金协会，北京100083

出版日期:2016-11-15 发布日期:2017-02-15
基金资助:
基金项目：国家自然科学基金项目（编号：51374034），“十二五”国家科技支撑计划项目（编号：2012BAB08B02）。

Study on Main Factors of Underflow Concentration in the Dynamics Thickening Process of Tailings

Gao Weihong¹，Wang Hongjiang^1,2，Chen Hui³，Yang Liuhua¹，Zhang Lei¹

1.School of Civil & Environmental Engineering，University of Science & Technology Beijing，Beijing 100083，China；2.Ministry of Education Key Laboratory of High Efficiency Mining & Safety for Metal Mines，Beijing 100083，China；3.China Gold Association，Beijing 100083，China

Online:2016-11-15 Published:2017-02-15

摘要/Abstract

摘要： 深锥浓密机是尾矿高效浓密脱水的关键设备，其生产过程中的泥层高度对压密效果具有重要影响，进而影响底流浓度，而目前缺少基于动态连续浓密过程的泥层高度对底流浓度的影响研究。笔者借助自制的小型深锥浓密机模拟系统进行了全尾砂连续动态浓密试验，探究了泥层高度和固体通量分别对动态浓密过程的影响。结果表明，在动态浓密过程中，底流浓度与泥层高度呈非线性正相关关系，泥层高度一定时，底流浓度最终趋于平稳；泥层高度稳定在60 cm时，由非连续浓密转变为连续浓密，底流浓度由60.3%降至56.4%；动态浓密过程中，泥层高度一定时，底流浓度与固体通量呈线性负相关关系。因此，泥层高度和固体通量对深锥浓密机的底流浓度具有一定的影响。

关键词: 深锥浓密机, 泥层高度, 底流浓度, 动态浓密

Abstract: Deepcone thickener is a key equipment for tailings' dewatering and thickening，and its mud height is a critical factor to the consolidation process in the production and then influences the underflow concentration.But there is lack of study on influence of mud height on underflow concentration on the basis of dynamic continuous thickening process at present.By applying innovative pilot-scale deep cone thickener simulation system to the study of tailings' dynamic continuous thickening experiment，the paper explored the impact of mud height and solid flux respectively on the process.The results showed that in the process of dynamic continuous thickening，the underflow concentration was nonlinearly and positively related to mud height.When it got to a certain height，the concentration inclined to steady state.At the height of 60 cm steadily，the discontinuous thickening was transformed into continuous thickening，the underflow concentration decreased from 60.3% to 56.4%.Besides，during the process，it was found that there was negative linear correlation between solid flux and underflow concentration at a certain height.The results all above indicated that mud height and solid flux had certain influence on deep cone thickener's underflow concentration.

Key words: Deep cone thickener, Mud height, Underflow concentration, Dynamic consolidation

高维鸿, 王洪江, 陈辉, 杨柳华, 张磊. 尾矿动态浓密过程中底流浓度主要影响因素研究[J]. 金属矿山, 2016, 45(11): 102-105.

GAO Wei-Hong, WANG Hong-Jiang, CHEN Hui, YANG Liu-Hua, ZHANG Lei. Study on Main Factors of Underflow Concentration in the Dynamics Thickening Process of Tailings[J]. Metal Mine, 2016, 45(11): 102-105.

[1]	田明明, 徐文彬, 王成龙, 阎少华. 玲珑金矿全尾砂絮凝沉降特性试验[J]. 金属矿山, 2019, 48(01): 120-124.
[2]	李刚. 水厂铁矿尾矿隔膜泵输送工艺研究与应用[J]. 金属矿山, 2018, 47(2): 107-111.
[3]	张鹏翔, 周兴龙, 兰希雄, 徐翔, 刘丕鸿, 马飞, 王昊伟. 振动斜板盒浓密机在铜街选矿厂尾矿浓缩中的应用[J]. 金属矿山, 2016, 45(05): 149-152.
[4]	陈辉, 王洪江, 吴爱祥, 王贻明. 哈尔滨某矿深锥浓密机的应用改造[J]. 金属矿山, 2015, 44(05): 158-161.
[5]	刘晓辉, 吴爱祥, 王洪江, 严庆文, 容苡. 膏体充填尾矿浓密规律初探[J]. 金属矿山, 2009, 39(09): 38-41.