急倾斜层状岩体巷道顶板膨胀型浆体注浆支护效果研究

金属矿山 ›› 2022, Vol. 51 ›› Issue (03): 57-64.

急倾斜层状岩体巷道顶板膨胀型浆体注浆支护效果研究

叶义成^1,2刘一鸣¹姚囝^1,2邓兴敏¹

1.武汉科技大学资源与环境工程学院，湖北武汉 430081；2.冶金矿产资源高效利用与造块湖北省重点实验室，湖北武汉 430081

出版日期:2022-03-15 发布日期:2022-04-01
基金资助:
国家自然科学基金项目（编号：51804224）；湖北省重点研发计划项目（编号：2020BCA082）

Research on the Effect of Expansive Slurry Grouting Support for Roadway Roof in Steeply Inclined Layered Rock Mass

YE Yicheng^1,2LIU Yiming¹YAO Nan^1,2DENG Xingmin¹

1.School of Resources and Environmental Engineering,Wuhan University of Science and Technology,Wuhan 430081,China;2.Hubei Key Laboratory for Efficient Utilization and Agglomeration of Metallurgic Mineral Resources,Wuhan 430081,China

Online:2022-03-15 Published:2022-04-01

摘要/Abstract

摘要： 为分析急倾斜层状岩体巷道顶板注浆后的支护效果，采用ABAQUS软件分别建立其顶板层理面普通型浆体注浆和膨胀型浆体注浆加固以及未注浆的数值分析模型，对比分析了不同注浆条件下巷道顶板的位移、应力与塑性应变的变化特征。开展了急倾斜层状岩体巷道顶板注浆相似模拟试验，在相似模型中设置了与数值模拟对应的位移与应力监测点，对比分析了普通型浆体注浆和膨胀型浆体注浆后的顶板位移及应力变化特征，并结合相似模拟试验现象分析了膨胀型浆体的注浆加固机理。研究表明：普通型浆体注浆和膨胀型浆体注浆条件下的顶板垂直位移较未注浆分别平均减少了19.7%和30.2%，膨胀型浆体注浆较普通型浆体注浆的垂直应力平均降低了18.4%。相似模拟试验中，巷道顶板位移及内部应力变化规律与数值模拟相吻合，膨胀型浆体注浆后的顶板承载能力和抵抗变形能力更强，加载后较普通型注浆下的顶板位移与应力更小。研究结果进一步表明,膨胀型浆体对于急倾斜层状岩体巷道顶板注浆加固具有良好的支护效果。

关键词: 急倾斜岩层, 膨胀型浆体注浆, 巷道围岩, 应力分布, 顶板位移

Abstract: In order to analyze the effect of slurry grouting support for roadway roof in steeply inclined layered rock mass,ABAQUS software was used to establish the numerical analysis models of regular slurry grouting,expansive slurry grouting reinforcement and nongrouting of the roof bedding surface.The variation characteristics of the displacement,stress and plastic strain of roadway roof under different grouting conditions were compared and analyzed.The similarity simulation test of roof grouting in steep layered rock roadway was carried out,displacement and stress monitoring points corresponding to numerical simulation were set in the similar test model,the variation characteristics of roof displacement and stress after regular slurry grouting and expansive slurry grouting were compared and analyzed.Combined with similar simulation test phenomenon,the grouting reinforcement mechanism of expansive slurry was analyzed.The results showed that the vertical displacement of roof under the conditions of regular grouting and expansive grouting was reduced by an average of 19.7% and 30.2% respectively compared with nongrouting,and the vertical stress was 18.4% lower than that of regular slurry grouting on average.In the similar simulation test,the variation law of roof displacement and internal stress was consistent with the numerical simulation.The bearing capacity and deformation resistance of the roof after expansive slurry grouting were stronger,and the displacement and stress of the roof after loading were smaller than those under regular grouting.The study results further indicated that the expansive slurry had a good support effect for the roof grouting reinforcement of roadway in steeply inclined layered rock mass.

Key words: steeply inclined rock mass,expansive slurry grouting,roadway surrounding rock,stress distribution,roof displacement

叶义成, 刘一鸣, 姚囝, 邓兴敏. 急倾斜层状岩体巷道顶板膨胀型浆体注浆支护效果研究[J]. 金属矿山, 2022, 51(03): 57-64.

YE Yicheng, LIU Yiming, YAO Nan, DENG Xingmin. Research on the Effect of Expansive Slurry Grouting Support for Roadway Roof in Steeply Inclined Layered Rock Mass[J]. Metal Mine, 2022, 51(03): 57-64.

[1]	吴　桐, 曹　朋, 路增祥. 无底柱分段崩落法进路宽度对其围岩稳定性的影响[J]. 金属矿山, 2024, 53(7): 9-.
[2]	吕靖烨, 王美君, 李　晟. 节理发育区巷道锚杆支护参数优化研究[J]. 金属矿山, 2024, 53(5): 220-.
[3]	牛海萍, 潘瑞凯, 于伟东, 沈玉旭. 复采工作面空巷充填力学响应规律与控制效果研究[J]. 金属矿山, 2024, 53(12): 165-.
[4]	徐振洋, 吴怡璇, 王雪松, 刘鑫, 郭连军, 柴青平. 旋压钻进破岩的应力特征研究[J]. 金属矿山, 2022, 51(10): 24-29.
[5]	于庆磊, 蒲江涌, 勒治华, 褚吉祥, 姜兆阳, 郜晓龙. 基于地质雷达的矽卡岩型铜铁矿巷道松动圈研究[J]. 金属矿山, 2021, 50(03): 46-53.
[6]	徐世达, 皇甫风成, 雷刚, 李元辉. 深部采场开采扰动下巷道围岩松动圈演化规律研究[J]. 金属矿山, 2019, 48(11): 14-19.
[7]	尤小明. 动静载叠加扰动对巷道围岩的冲击破坏[J]. 金属矿山, 2017, 46(06): 56-60.
[8]	杨逾, 孙艺丹, 张培兰. 兰家沟钼矿巷道围岩稳定性分析[J]. 金属矿山, 2016, 45(08): 69-74.
[9]	刘艳章, 陈小强, 潘世华, 邹晓甜, 张群, 张丙涛. 基于开拓巷道稳定性分析的泥河铁矿阶段开采顺序研究[J]. 金属矿山, 2015, 44(08): 6-12.
[10]	叶红, 陈燕平. 基于Mindlin基本解的压力型锚索受力分析[J]. 金属矿山, 2015, 44(04): 114-118.
[11]	胡军, 王凯凯, 夏治国. 分层鱼群优化支持向量机预测巷道围岩松动圈厚度[J]. 金属矿山, 2014, 43(11): 31-34.
[12]	曹野. 金属矿山巷道围岩安全监测诊断预警体系[J]. 金属矿山, 2014, 43(09): 126-131.
[13]	张海磊, 刘涛, 郭生茂, 孙嘉, 王成财, 周健强. 隔离矿柱巷道围岩松动圈分布规律的测试[J]. 金属矿山, 2014, 43(07): 151-155.
[14]	张兰翔, 查文华, 王昆. 裂隙岩体本构模型及数值模拟研究与应用[J]. 金属矿山, 2013, 42(12): 48-51.
[15]	王德永, 袁艳斌, 陈颖. 基于GA-BPNN的巷道围岩变形模量预测[J]. 金属矿山, 2013, 42(03): 9-13.

扫码分享