磁化浸金溶液提高某低品位金矿石滴淋堆浸效果研究

金属矿山 ›› 2022, Vol. 51 ›› Issue (03): 105-110.

磁化浸金溶液提高某低品位金矿石滴淋堆浸效果研究

代豪¹萨伍提·阿卜杜热伊木¹孙春宝¹寇珏¹胡阳¹邢成军²李冠华²白杨²

1.北京科技大学土木与资源工程学院，北京 100083；2.内蒙古太平矿业有限公司，内蒙古巴彦淖尔 014010

出版日期:2022-03-15 发布日期:2022-04-02
基金资助:
国家自然科学基金项目(编号：51974016)

Study on Improving the Effect of Drip and Heap Leaching of a Lowgrade Gold Mines with Magnetized Gold Leaching Solution

DAI Hao¹SAWUTI Abudureyimu¹SUN Chunbao¹KOU Jue¹HU Yang¹XING Chengjun²LI Guanhua²BAI Yang²

1.School of Civil and Resources Engineering,University of Science and Technology Beijing,Beijing 100083,China;2.Inner Mongolia Taiping Mining Co.,Ltd.,Bayannaoer 014010,China

Online:2022-03-15 Published:2022-04-02

摘要/Abstract

摘要： 某低品位金矿金品位为0.65 g/t，滴淋堆浸浸出率较低。为考察磁化处理对该金矿石滴淋堆浸效果的影响，进行了磁化处理条件试验，考察了Ca2+、Mg2+及Na+等杂质离子浓度对溶液磁化前后表面张力的影响，探究了磁化浸金溶液对低品位金矿滴淋堆浸效果的影响及机理。结果表明：①磁化可以降低去离子水的表面张力，磁感应强度为1 T时适宜的磁化条件为磁化时间15 min、水流速度300 r/min，该条件下磁化后去离子水的磁化效果仅维持50 min。②溶液中Ca2+、Mg2+会使溶液的表面张力不同程度的增大，且表面张力随离子浓度的增大而增大，而磁化可以在一定程度上减弱或消除这类离子的影响；尽管Na+的存在也会降低溶液的表面张力，但溶液表面张力受Na+浓度的影响较小。③磁化后的氰化钠浸金液与矿石的接触角更小，磁化有利于氰化钠浸金液在矿石表面的铺展。④浸金液的磁化处理有利于提高矿石的金浸出率，金浸出率由58.04%提高至62.21%，增幅达4.17个百分点。

关键词: 低品位金矿, 磁化处理, 表面张力, 离子浓度, 滴淋浸出, 浸出率

Abstract: The gold grade of a low grade gold mine is 0.65 g/t,and the leaching rate of drip heap is low.In order to investigate the effect of magnetization treatment on the drip heap leaching effect of the gold ore,the magnetization treatment condition test was carried out to investigate the effect of Ca2+,Mg2+ and Na+ concentration on the surface tension before and after the solution magnetization,and explore the effect and mechanism of magnetization solution on the drip heap leaching effect of lowgrade gold ore.The results showed that:① Magnetization can reduce the surface tension of deionized water.When the magnetic induction intensity is 1 T,the suitable magnetization conditions are magnetization time of 15 min and water flow speed of 300 r/min.Under these conditions,the magnetization effect of deionized water can only be maintained for 50 min.② Ca2+ and Mg2+ in solution can increase the surface tension of solution to varying degrees,and the surface tension increases with the increase of ion concentration.Magnetization can reduce or eliminate the influence of such ions to a certain extent.Although the presence of Na+ also reduced the surface tension of the solution,the surface tension of the solution was less affected by the concentration of Na+.③ After magnetization,the contact angle between the sodium cyanide leaching solution and the ore is smaller,and the magnetization is conducive to the spread of the sodium cyanide leaching solution on the surface of the ore.④ Magnetization treatment of gold leaching solution is beneficial to improve the gold leaching rate of ore,and the gold leaching rate increases from 58.04% to 62.21%,with an increase of 4.17 percentage points.

Key words: low grade gold ores, magnetization treatment, surface tension, iron concentration, drip and head leaching, leaching rate

代豪, 萨伍提·阿卜杜热伊木, 孙春宝, 寇珏, 胡阳, 邢成军, 李冠华, 白杨. 磁化浸金溶液提高某低品位金矿石滴淋堆浸效果研究[J]. 金属矿山, 2022, 51(03): 105-110.

DAI Hao, SAWUTI Abudureyimu, SUN Chunbao, KOU Jue, HU Yang, XING Chengjun, LI Guanhua, BAI Yang. Study on Improving the Effect of Drip and Heap Leaching of a Lowgrade Gold Mines with Magnetized Gold Leaching Solution[J]. Metal Mine, 2022, 51(03): 105-110.

[1]	李　铭, 杨　斌, 胡　军, 夏治国, 罗　昌. 尾矿水浸泡对砂岩结构及力学特性影响研究[J]. 金属矿山, 2024, 53(6): 31-.
[2]	杨奇霖　卿海天　张　杰　张志远　居殿春　张　俊　堵伟桐. 含钒四氯化钛精制尾渣锰化焙烧制备V2O5工艺研究[J]. 金属矿山, 2024, 53(01): 304-309.
[3]	沈楼燕, 李文化, 胡申琛, 赵红波, 申丽. SO₂ 气体介入中非某铜钴矿钴还原浸出反应的新工艺探讨 #br#[J]. 金属矿山, 2023, 52(05): 276-281.
[4]	李凤久, 王仁贺, 贾清梅, 叶杨海, 孟克难, 徐彬. 磁化油酸钠溶液对气泡特性影响研究[J]. 金属矿山, 2023, 52(04): 79-85.
[5]	李凤久, 孔亚然, 赵留成, 贾清梅. 药剂的磁化处理对赤铁矿浮选的影响及机理研究[J]. 金属矿山, 2022, 51(09): 87-93.
[6]	周龙, 胡鄂明, 张聪, 雷治武, 胡芳, 王红强, 王清良. 含铀难浸碱渣拌酸熟化强化浸出试验研究[J]. 金属矿山, 2022, 51(05): 148-152.
[7]	金永朋, 李艳军, 袁帅, 刘杰. 新疆某难处理含钒石煤焙烧—酸浸提钒试验研究[J]. 金属矿山, 2021, 50(09): 96-101.
[8]	董振海, 杨晓峰, 刘双安, 李艳军 . 风化壳型钒钛磁铁矿精矿直接酸浸提钒试验及机理研究[J]. 金属矿山, 2020, 49(12): 108-113.
[9]	姜永良, 付泳贺, 姜效军, 苏拓宇. 组合阴离子捕收剂对石英的吸附机理研究 [J]. 金属矿山, 2020, 49(11): 118-123.
[10]	向军, 周文波, 熊玮, 程晖, 朱照强, 徐敏. 磁化处理对微细粒赤铁矿浮选的影响与机理研究[J]. 金属矿山, 2020, 49(08): 76-82.
[11]	陈克强, 印万忠, 饶峰, 马英强, 吴洁, 缪彦. 地质聚合反应制团对低品位铜矿石高压辊破碎—生物浸出的影响[J]. 金属矿山, 2020, 49(07): 105-110.
[12]	李青青, 周文波, 李赛, 陶黎明, 余凡, 张力. 油酸钠体系中磁化处理对萤石浮选行为的影响[J]. 金属矿山, 2019, 48(07): 108-112.
[13]	杨思敏, 寇珏, 张晓亮, 孙春宝. 赞比亚某氧化铜矿石的硫酸酸浸研究[J]. 金属矿山, 2019, 48(05): 79-83.
[14]	艾纯明, 孙萍萍, 王贻明, 刘超. 表面活性剂在溶浸采矿中的研究与应用现状[J]. 金属矿山, 2019, 48(05): 9-13.
[15]	李超, 覃忠祥, 宋振纶, 张杰, 王海. 刚果（金）某氧化钴矿还原酸浸试验[J]. 金属矿山, 2019, 48(04): 93-96.

扫码分享