焙烧制度对煤泥-浸锌渣冷固结球团还原行为的影响

金属矿山 ›› 2015, Vol. 44 ›› Issue (01): 161-165.

焙烧制度对煤泥-浸锌渣冷固结球团还原行为的影响

杨慧芬¹，蒋蓓萍¹，袁运波²，王亚运¹，苑修星¹

1.北京科技大学土木与环境工程学院，北京 100083；2.江西理工大学南昌校区建设与资源工程系，江西南昌 330013

出版日期:2015-01-15 发布日期:2015-07-28

Effect of Roasting System on Reduction Behavior of Cold Bond Pellets Made of Coal Slime-Zinc Leaching Residue

Yang Huifen¹，Jiang Beiping¹，Yuan Yunbo²，Wang Yayun¹，Yuan Xiuxing¹

1.School of Civil and Environmental Engineering，University of Science and Technology Beijing，Beijing 100083，China;2.Department of Civil and Resources Engineering，Nanchang Campus，Jiangxi University of Science and Technology，Nanchang 330013，China

Online:2015-01-15 Published:2015-07-28

摘要/Abstract

摘要： 基于直接还原法探讨了焙烧制度对煤泥-浸锌渣冷固结球团中锌、铅挥发率和铁金属化率的影响，分析了焙烧制度对球团中含锌、铅、铁化合物相变的影响，试验确定了焙砂磨矿—弱磁选回收其中铁的工艺和效果。结果表明：在1 250 ℃焙烧90 min，可使球团中锌、铅的挥发率分别达到98.87%、95.39%，铁的金属化率达到98.66%；焙砂中未见锌、铅单质及其化合物，只存在大量的金属铁，且金属铁颗粒多数大于30 μm；焙砂采用2段磨矿、2段弱磁选流程处理，可同时获得含铁91.20%、回收率为30.32%的金属铁粉和铁品位为61.58%、回收率为50.01%的铁精矿，铁总回收率达80.33%。

关键词: 煤泥, 浸锌渣, 冷固结球团, 直接还原, 焙烧制度

Abstract: The effect of roasting system on lead and zinc evaporation rate，iron metallization rate of cold bond pellets made of coal slime-zinc leaching residue was investigated based on direct reduction.The influence of roasting system on phase change of Zn，Pb and Fe compounds in the pellets was analyzed.The process of grinding-low intensity magnetic separation for iron recovering is determined according experiments.Results show that calcined at 1 250 ℃for 90 min，the evaporation rate of lead 95.39% and zinc 98.87%，iron metallization rate of 98.66% were obtained.In the roasting products，diffraction peak of Zn，Pb monomer metals and its compounds disappeared，while more iron emerged，and majority of which are greater than 30 μm in particle size.Metallic iron powder with iron grade of 91.20% and recovery of 30.32%，and iron concentrate with iron grade of 61.58% and recovery of 50.01% were obtained through two stage grinding，two stage low intensity magnetic separation process，and the total iron recovery reaches 80.33%.

Key words: Coal slime, Zinc leaching residue, Cold bonded pellets, Direct reduction, Roasting system

杨慧芬, 蒋蓓萍, 袁运波, 王亚运, 苑修星. 焙烧制度对煤泥-浸锌渣冷固结球团还原行为的影响[J]. 金属矿山, 2015, 44(01): 161-165.

YANG Hui-Fen, JIANG Bei-Ping, YUAN Yun-Bo, WANG Ya-Yun, YUAN Xiu-Xing. Effect of Roasting System on Reduction Behavior of Cold Bond Pellets Made of Coal Slime-Zinc Leaching Residue[J]. Metal Mine, 2015, 44(01): 161-165.

[1]	杨慧芬, 姜美苓, 高春庆, 冯筱迪, 周轶臣, 李萱. 赤铁矿渣—煤泥铁碳基复合材料的制备及除Cr(Ⅵ )性能研究[J]. 金属矿山, 2023, 52(01): 269-275.
[2]	高恩霞, 房青松, 耿超, 蒋曼, 孙体昌. 钛磁铁矿直接还原—磁选钛铁分离主要影响因素探析[J]. 金属矿山, 2022, 51(11): 92-100.
[3]	朱超波, 黄自力, 杨福, 袁晨光, 刘楚玉, 黄涛, 肖硕. 某磁铁精矿内配碳直接还原试验研究[J]. 金属矿山, 2022, 51(07): 164-169.
[4]	郑金, 王洪凯李斌川, 陈建设, 刘奎仁, 韩庆, . 辽宁某氰化尾渣中铁、铅综合回收试验研究[J]. 金属矿山, 2021, 50(11): 115-120.
[5]	王英硕 , 黄武胜 , 刘伟然 , 延黎 , 吴世超 , 孙体昌 . 回转窑直接还原工艺处理国外某高磷鲕状赤铁矿的工业试验[J]. 金属矿山, 2021, 50(04): 106-112.
[6]	吴世超 , 孙体昌 , 李正要, 徐承焱, 李小辉. 高磷铁矿石直接还原—磁选研究进展[J]. 金属矿山, 2021, 50(02): 58-64.
[7]	叶子青, 黄自力, 石家力, 袁晨光, 刘楚玉, 朱超波. 碳热还原法从铜渣中回收铁钼合金[J]. 金属矿山, 2020, 49(11): 106-112.
[8]	邱廷省, 周丽萍, 李国栋. 铜冶炼渣直接还原焙烧—磁选回收铜、铁试验研究[J]. 金属矿山, 2020, 49(09): 202-207.
[9]	吴世超, 孙体昌, 杨慧芬. 国外某高磷鲕状赤铁矿直接还原—磁选降磷研究[J]. 金属矿山, 2019, 48(11): 109-114.
[10]	刘占华, 陈文亮, 丁银贵, 曹志成, 吴道洪, 余文. 铜渣转底炉直接还原回收铁锌工艺研究[J]. 金属矿山, 2019, 48(05): 183-187.
[11]	杨慧芬, 李兆峰, 付鹏, 张鸽. 罐底油泥冷固结并还原铁矾渣的可行性研究[J]. 金属矿山, 2019, 48(05): 177-182.
[12]	何威, 曾维伟, 陈向, 廖德华. 某菱铁矿石直接还原—弱磁选试验[J]. 金属矿山, 2019, 48(03): 86-89.
[13]	朱德庆, 严欣程, 潘建, 郭正启. 某高品位磁铁精矿球团预热—煤基直接还原研究[J]. 金属矿山, 2019, 48(03): 79-85.
[14]	贾晓钊, 雷国元, 余晓东, 向锐, 毛绍波, 季佳善. 利用矿山废弃高塑性红黏土制备轻质陶粒的研究[J]. 金属矿山, 2018, 47(04): 192-196.
[15]	李国栋, 彭建成, 郭艳华, 廖雪珍. 西北某高铅银浸锌渣中银的浮选回收试验[J]. 金属矿山, 2016, 45(11): 177-180.

扫码分享