絮凝剂对细粒铁精矿沉降效果的影响

金属矿山 ›› 2015, Vol. 44 ›› Issue (10): 95-99.

絮凝剂对细粒铁精矿沉降效果的影响

陈婉琦^1,2，张芹^1,2，王天正^1,2，戴柯进^1,2

1.武汉科技大学资源与环境工程学院，湖北武汉 430081；2.绿色制造与节能减排科技研究中心，湖北武汉 430081

出版日期:2015-10-15 发布日期:2015-11-20

Influence of Flocculants on Sedimentation Effect of Ultrafine Hematite

Chen Wanqi^1,2，Zhang Qin^1,2，Wang Tianzheng^1,2，Dai Kejin^1,2

1.College of Resources and Environmental Engineering，Wuhan University of Science and Technology，Wuhan 430081，China；2.Research Center of Green Manufacturing，Energy Conservation and Emission Reduction Technologies， Wuhan University of Science and Technology，Wuhan 430081，China

Online:2015-10-15 Published:2015-11-20

摘要/Abstract

摘要： 为改善细粒赤铁矿精矿在浓缩脱水过程中存在的沉降时间长、过滤速率低、穿漏现象严重、滤饼含水率高等问题，以巴西某赤铁矿精矿为研究对象，考察了絮凝剂种类及用量、矿浆pH、温度及混匀程度等对赤铁矿沉降行为的影响。结果表明：絮凝剂添加量对赤铁矿精矿沉降效果有显著影响，用量过低时，对改善沉降效果不明显，用量过高时会产生“胶体保护”，沉降速率不再随絮凝剂用量增加而提高；聚丙烯酸钠类絮凝剂在酸性条件下对精矿的沉降效果好，聚丙烯酰胺类在碱性条件下沉降效果较好；温度较低时，不利于絮凝剂与矿物颗粒作用，沉降效果差，温度过高时，絮凝剂发生降解，沉降效果变差；翻转混匀次数少时絮凝剂分子分散不好，精矿沉降速率低，在充分混合时，细粒赤铁矿沉降速率达到最大值，进一步增加翻转混匀次数，会造成絮团断裂，精矿沉降速率降低。试验结果对赤铁矿精矿沉降时选取合适的絮凝剂，提高精矿沉降效果具有重要意义。

关键词: 细粒赤铁矿, 絮凝剂, 沉降速率

Abstract: In order to improve the problems of long settling time，low filtration rate，severe wear leakage phenomenon，low content in filter cake during thickening and dehydration for fine grained hematite concentrate.Effects of types and dosage of flocculants，slurry pH，temperature，and degree of mixedness on the sedimentation behavior were studied，using an iron concentrate from Brazil as research object.The results indicated that：there were significant influence on sedimentation of hematite concentrate by adjusting flocculants addition，for too low addition have no obvious improvement on the sedimentation rate，with excessive addition could initiate colloid protecting，and the sedimentation velocity will not increase with dosage increase of flocculants.Sodium polyacrylate flocculants have good settling performance in alkaline conditions，while polyacrylamide flocculants have good settling performance in acidic condition.Hypothermia have disadvantage in improving the sedimentation rate，hyperthermia would lead to degradation of flocculants.Sufficient reversal and mixing was conducive to sedimentation，excessive mixing will worsen sedimentation effects.The results have important implications for suitable flocculant selection in iron concentrate settling and improve the concentrate sedimentation.

Key words: Ultrafine hematite, Flocculants, Sedimentation rate

陈婉琦, 张芹, 王天正, 戴柯进. 絮凝剂对细粒铁精矿沉降效果的影响[J]. 金属矿山, 2015, 44(10): 95-99.

CHEN Wan-Qi, ZHANG Qin, WANG Tian-Zheng, DAI Ke-Jin. Influence of Flocculants on Sedimentation Effect of Ultrafine Hematite[J]. Metal Mine, 2015, 44(10): 95-99.

[1]	张　爽, 李文博, 程绍凯, 周立波. 淀粉及其改性产品对东鞍山细粒赤铁矿聚团 —磁选的影响[J]. 金属矿山, 2024, 53(3): 83-.
[2]	田德彬, 马文荣, 杜　亮, 陈　宏, 陈亚利, 张　攀, 孙　艺, 肖　奔, 夏英杰, 常兴华. 矿物载体絮凝对高碱高浊废水沉降性能的影响[J]. 金属矿山, 2024, 53(12): 281-.
[3]	杨志超, 韩英棋, 滕青, 张郭阳. Ca( Ⅱ ) -XG 配合物选择性絮凝赤铁矿与石英的作用机理[J]. 金属矿山, 2023, 52(05): 129-136.
[4]	刘桂鑫, 刘奎仁, 陈建设, 李斌川, 韩庆. 铜熔炼烟尘中铜的回收试验研究[J]. 金属矿山, 2022, 51(11): 147-153.
[5]	张伦旭, 孙博远, 金丹, 马艺闻. 细粒赤铁矿对淀粉与石英吸附特性影响及机理研究[J]. 金属矿山, 2022, 51(07): 175-180.
[6]	李明阳, 梁锐, 杨诚, 张晨 , 张鹏鹏 , 童雄 . 海藻酸钠在选矿领域的应用研究进展[J]. 金属矿山, 2021, 50(12): 11-20.
[7]	杨志超 , 滕青, 祝瑄 , 李官超 . 多糖微生物絮凝剂对方解石与闪锌矿的絮凝作用及机理[J]. 金属矿山, 2021, 50(10): 108-113.
[8]	荆晓东 , 朱庚杰 , 桑来发, 宋泽普, 吴再海. 絮凝剂对超细尾砂胶结充填体性能的影响[J]. 金属矿山, 2021, 50(10): 61-66.
[9]	张美道, 饶运章, 徐文峰, 王文涛, 李江红 . 某矿全尾砂浆静态絮凝沉降试验研究[J]. 金属矿山, 2020, 49(12): 50-54.
[10]	梁效, 王勇海, 吴天骄, 赵笑益. 无机和有机絮凝剂复配对铁尾矿沉降特性研究[J]. 金属矿山, 2020, 49(11): 129-133.
[11]	向军, 周文波, 熊玮, 程晖, 朱照强, 徐敏. 磁化处理对微细粒赤铁矿浮选的影响与机理研究[J]. 金属矿山, 2020, 49(08): 76-82.
[12]	刘军, 杨任新, 王炬, 陆虎. 姑山极微细粒赤铁矿石选矿工艺流程改进探索试验[J]. 金属矿山, 2018, 47(10): 70-75.
[13]	潘登, 张芹, 吴梅, 曾睿, 李炼. 油酸钠体系下细粒赤铁矿精矿过滤影响因素研究[J]. 金属矿山, 2018, 47(01): 125-127.
[14]	曾睿, 张芹, 苟宝, 潘登, 李炼. 钙镁离子对细粒赤铁矿絮凝行为的影响[J]. 金属矿山, 2018, 47(01): 84-87.
[15]	龙伟, 张芹, 向贵锋, 张进, 潘登, 曾睿. 水硬度对细粒赤铁矿絮凝沉降效果的影响[J]. 金属矿山, 2016, 45(12): 134-137.

扫码分享