贵州锦丰金矿胶固粉—分级尾砂充填技术研究与应用

金属矿山 ›› 2022, Vol. 51 ›› Issue (09): 43-48.

贵州锦丰金矿胶固粉—分级尾砂充填技术研究与应用

贾住平¹郑禄璟² 胡亚飞³ 郑禄林⁴ 荣鹏4

1. 贵州职业技术学院,贵州贵阳 550023;2. 贵州锦丰矿业有限公司,贵州贵阳 562204;3. 北京科技大学土木与资源工程学院,北京 100083;4. 贵州大学矿业学院,贵州贵阳 550025

出版日期:2022-09-15 发布日期:2022-10-13
基金资助:
贵州省科技支撑计划项目(编号:黔科合支撑[2021]一般 516)

Research and Application of Filling Technology with Glue Powder and Graded Tailing in Jinfeng Gold Mine,Guizhou Province

JIA Zhuping¹ZHENG Lujing²HU Yafei³ZHENG Lulin⁴ RONG Peng⁴

1. Guizhou Vocational Technology Institute,Guiyang 550023,China;2. Guizhou Jinfeng Mining Limited,Guiyang 562204,China;3. School of Civil and Resources Engineering,University of Science and Technology Beijing,Beijing 100083,China;4. Mining College of Guizhou University,Guiyang 550025,China

Online:2022-09-15 Published:2022-10-13

摘要/Abstract

摘要： 针对贵州锦丰金矿超细尾砂充填体强度低及充填成本高等问题,开展了旋流器底流产率为 65%时的分级尾砂粒级组成分析、不同料浆浓度及不同胶凝剂掺量下的充填体力学特性研究,并根据充填倍线的不同对胶固粉掺量进行配合比优选。结果表明:胶固粉化学物质含量达到一般固废要求,可以用于井下充填;尾砂矿物组成主要为石英,有利于提高充填体强度;同等强度和流动性要求下,胶固粉掺量仅为水泥掺量的 1 / 2;胶固粉掺量为 5. 5%时,充填体养护 7 d 的试件强度达到 0. 36 MPa,满足设计要求;添加胶固粉的充填体养护龄期超过 28 d 后强度逐渐降低,因此不宜将胶固粉用于打底充填。根据当地水泥和胶固粉单价进行技术经济指标对比,采用胶固粉代替水泥充填可节约大量充填成本,可为类似矿山充填提供有效参考。

关键词: 分级尾砂, 胶固粉, 充填体强度, 打底充填

Abstract: Aiming at the problems of low strength and high filling cost of ultra-fine tailings backfill in Jinfeng Gold Mine, Guizhou Province,the particle composition analysis of graded tailings when the abortion rate of cyclone bottom was 65% and the physical characteristics of backfill with different slurry concentrations and glue powder dosage were carried out. The mixing ratio of glue powder was optimized according to the different filling times. The results showed that the chemical content of glue powder meets the requirements of general solid waste and can be used for underground filling. The mineral composition of tailings is mainly quartz,which is beneficial to improve the strength of backfill. Under the requirements of the same strength and fluidity,the glue powder dosage is half of the cement dosage. When the dosage of glue powder is 5.5%,the strength of backfill with curing period of 7 d reaches 0. 36 MPa,which meets the design requirement. The strength of filling body with glue powder decreases gradually after curing period of more than 28 d,so it is not suitable to use glue powder for render filling. According to the comparison of technical and economic indicators between local cement and glue powder by unit price,the use of glue powder instead of cement filling can save a lot of filling cost,which can provide effective reference for similar mine filling.

贾住平, 郑禄璟, 胡亚飞, 郑禄林, 荣鹏. 贵州锦丰金矿胶固粉—分级尾砂充填技术研究与应用[J]. 金属矿山, 2022, 51(09): 43-48.

JIA Zhuping, ZHENG Lujing, HU Yafei, ZHENG Lulin, RONG Peng. Research and Application of Filling Technology with Glue Powder and Graded Tailing in Jinfeng Gold Mine,Guizhou Province[J]. Metal Mine, 2022, 51(09): 43-48.

[1]	林景尚, 王谦源, 陈宁青, 王海龙. 大空区低成本充填处理方法研究与实践[J]. 金属矿山, 2024, 53(6): 85-.
[2]	陈宁青. 大空区充填体结构稳定分析与强度设计[J]. 金属矿山, 2023, 52(04): 33-36.
[3]	林敏, 袁庆盟, 王谦源. 盘区矿柱回收与充填体稳定性的数值模拟研究[J]. 金属矿山, 2022, 51(06): 24-28.
[4]	李志朝, 王剑 , 郏威, 张敏哲, 彭青松, 王勇. 罗河铁矿全尾砂胶结充填配比优化试验研究[J]. 金属矿山, 2021, 50(06): 136-140.
[5]	张杰 , 孙载磊, 储昌欢 . 不同灰砂比条件下机制砂率对充填体强度影响试验研究[J]. 金属矿山, 2021, 50(04): 40-44.
[6]	杨晓炳, 高谦, 王永定, 何建元. 早强剂对固结粉胶凝材料混合骨料充填体强度的影响[J]. 金属矿山, 2020, 49(09): 48-53.
[7]	郭斌, 梁峰, 吴凡, 涂光富, 高谦. 高官营铁矿高强度新型胶凝材料研究[J]. 金属矿山, 2019, 48(11): 8-13.
[8]	梁峰, 高谦, 丛革臣, 杨寿军. 思山岭铁矿超细全尾砂固结粉充填胶凝材料研究[J]. 金属矿山, 2019, 48(08): 198-200.
[9]	吴爱祥, 姜关照, 王贻明. 矿山新型充填胶凝材料概述与发展趋势[J]. 金属矿山, 2018, 47(03): 1-6.
[10]	齐兆军, 宋泽普, 寇云鹏, 刘超, 荆晓东, 杨纪光. 某矿山全尾砂似膏体充填配比试验研究[J]. 金属矿山, 2018, 47(01): 68-72.
[11]	王志军, 吕文生, 杨鹏, 王志凯, 王金海. 充填体强度的支持向量机设计匹配模型[J]. 金属矿山, 2016, 45(11): 34-38.
[12]	王安福, 杨志强, 高谦, 孙光华. 某铁矿胶固粉与水泥胶结充填体强度对比试验[J]. 金属矿山, 2016, 45(07): 109-112.
[13]	邱景平, 杨蕾, 邢军, 孙晓刚, 王强. 充填体损伤本构模型的建立及其强度的确定方法[J]. 金属矿山, 2016, 45(05): 48-51.
[14]	姜金洁, 张建华, 尹东升, 胡晓倩, 周勇. 黄麦岭磷矿胶结充填开采配比试验及数值模拟[J]. 金属矿山, 2016, 45(04): 36-41.
[15]	甘德清, 申梦飞, 孙光华, 刘志义, 陈超, 何水清. 金属矿山充填体强度分布规律实验研究[J]. 金属矿山, 2016, 45(04): 32-35.

扫码分享