鄂西高磷赤铁矿尾矿制备烧结砖试验研究

金属矿山 ›› 2009, Vol. 39 ›› Issue (05): 175-178.

鄂西高磷赤铁矿尾矿制备烧结砖试验研究

王梅英，张一敏，陈铁军，陈永亮，陈章，赵云良

武汉理工大学

出版日期:2009-05-15 发布日期:2011-11-09
基金资助:
* “十一五”国家科技支撑计划项目(编号：2007BAB15B00)。

Research on Making Fired Bricks with High Phosphorous Hematite Tailings from West Hubei

Wang Meiying，Zhang Yimin，Chen Tiejun，Chen Yongliang，Chen Zhang，Zhao Yunliang

Wuhan University of Technology

Online:2009-05-15 Published:2011-11-09

摘要/Abstract

摘要： 鄂西赤铁矿矿石储量大，属于高磷微细粒嵌布的难选鲕状矿，其尾矿产生量大、粒度细、铁含量高且回收难度很大，硅铝含量偏低，直接堆放将会对环境造成污染，必须加以综合利用。在对鄂西高磷赤铁矿尾矿基本特性综合分析的基础上，采用压制成型法，进行了用其制备烧结砖的试验研究。结果表明，在成型水分12%～15%、成型压力20～25 MPa，烧结温度950～1 050 ℃等最佳条件下，利用鄂西铁矿尾矿，可以制备MU20以上标号的普通烧结砖，其烧成制品为红色,颜色一致性好。

关键词: 高磷赤铁矿尾矿, 压制成型法, 烧结砖

Abstract: West Hubei has a large hematite ore reserve, which is a kind of high phosphorous fine-sized refractory oolitic ore. Its beneficiation produces a large amount of hematite tailings that have a fine size, high content of iron which is difficult to recover and low silicon-aluminum content. Their direct disposal can pollute the environment and therefore, a comprehensive utilization of these tailings should be made. Based on the analysis of their basic properties, test research was made on using them to make fired bricks by press-forming. The results show that at the optimal conditions of a 12%～15% forming moisture, 20～25 MPa forming pressure, 950～1 050 ℃ firing temperature, above MU2-class common fired bricks can be made with this kind of hematite tailings, with their fired products having a uniform red color.

Key words: High phosphorous hematite ore, Press-forming method, Fired bricks

王梅英, 张一敏, 陈铁军, 陈永亮, 陈章, 赵云良. 鄂西高磷赤铁矿尾矿制备烧结砖试验研究[J]. 金属矿山, 2009, 39(05): 175-178.

WANG Mei-Ying, ZHANG Yi-Min, CHEN Tie-Jun, CHEN Yong-Liang, CHEN Zhang, ZHAO Yun-Liang. Research on Making Fired Bricks with High Phosphorous Hematite Tailings from West Hubei[J]. Metal Mine, 2009, 39(05): 175-178.

扫码分享