一种井下防灭火多相凝胶泡沫材料的研制

金属矿山 ›› 2013, Vol. 42 ›› Issue (04): 147-150.

一种井下防灭火多相凝胶泡沫材料的研制

张雷林^1,2，毛桃良³，秦波涛^1,2，申宏敏^1,2

1.中国矿业大学安全工程学院；2.煤矿瓦斯与火灾防治教育部重点实验室；3.国投昔阳能源有限责任公司黄岩汇煤矿

出版日期:2013-04-15 发布日期:2013-05-13
基金资助:
* 国家自然科学基金项目（编号：50904066），教育部新世纪优秀人才支持计划项目（编号：NCET-09-0729），江苏省普通高校研究生科研创新计划项目（编号：CXZZ12-0959）。

Preparation of a Multi-phase Foamed Gel for Underground Fire Prevention Fire Control

Zhang Leilin^1,2，Mao Taoliang³，Qin Botao^1,2，Shen Hongmin^1,2

1.Faculty of Safety Engineering, China University of Mining & Technology；2.Ministry of Education Key Laboratory of Gas and Fire Control for Coal Mines；3.Huangyanhui Coal Mine，Sdic Xiyang Energy Company Limited

Online:2013-04-15 Published:2013-05-13

摘要/Abstract

摘要： 以4种发泡剂（F1、F2、F3和F4）、稠化剂H、交联剂AL和大屯煤电公司粉煤灰为原料制备煤矿井下防灭火用多相凝胶泡沫材料，着重研究了发泡剂复配方案及用量、稠化剂H与交联剂Al的配比及用量、不同发泡方式（机械搅拌发泡和压缩氮气发泡）对材料发泡性能的影响。结果表明，将F1和F3按1∶1的质量比进行复配，在复配发泡剂与水的质量比为4‰、稠化剂H和交联剂AL与水的质量比均为3‰、水灰比为5∶1的条件下采用压缩气体发泡方式进行发泡，材料产生的多相凝胶泡沫性能最佳。

关键词: 煤矿井下防灭火, 多相凝胶泡沫, 泡沫性能

Abstract: With four kinds of foaming agent (F1, F2, F3 and F4), the thickener H, the cross-linking agent AL and fly ash from Datun Coal and Electricity Company as raw materials, the multiphase gel foam for the underground fire prevention of coal mine is prepared, focusing on studying the proportion and dosage of foaming agents, the mixture ratio and dosage of thickener H and cross-linking agent Al, and influences of different foaming (foaming by mechanical stirring and foaming by compressed nitrogen) on the foam properties of materials. The results show that under the conditions of the mass ratio of F1 and F3 at 1∶1, the mass ratio of complex foaming agent and water at 4‰, the mass ratio of thickener H, cross-linking agent AL and water at 3‰, and the water-cement ratio of 5∶1, the multiphase gel foam with highest performance is produced by the compressed gas foaming.

Key words: Underground fire prevention of coal mine, Multiphase gel foam, Foam properties

张雷林, 毛桃良, 秦波涛, 申宏敏. 一种井下防灭火多相凝胶泡沫材料的研制[J]. 金属矿山, 2013, 42(04): 147-150.

ZHANG Lei-Lin, MAO Tao-Liang, QIN Bo-Tao, SHEN Hong-Min. Preparation of a Multi-phase Foamed Gel for Underground Fire Prevention Fire Control[J]. Metal Mine, 2013, 42(04): 147-150.

[1]	刘文宝, 甘琦强, 陈猛强, 刘文刚, 沈岩柏. 在锂云母浮选中新型阴阳离子组合捕收剂的泡沫性能研究[J]. 金属矿山, 2024, 53(7): 104-.
[2]	朱一民, 马玉宁, 杨雪莹, 谷晓恬, 李文博. 新型捕收剂 DXY 对石英的浮选及泡沫性能研究[J]. 金属矿山, 2022, 51(10): 95-100.
[3]	朱一民, 杨雪莹, 乘舟越洋, 高子蕙, 韩跃新. 不同胺类捕收剂泡沫性能及其机理研究[J]. 金属矿山, 2020, 49(07): 99-104.
[4]	高子蕙, 朱一民. 疏水碳链长度对胺类捕收剂起泡性能的影响研究[J]. 金属矿山, 2019, 48(02): 129-134.
[5]	禹东方, 陈学习, 马尚权, 柏松. 测压钻孔三相泡沫密封液的试验研究[J]. 金属矿山, 2009, 39(09): 165-168.

扫码分享