欢迎访问《金属矿山》杂志官方网站,今天是 分享到:

金属矿山 ›› 2018, Vol. 47 ›› Issue (03): 57-61.

• 采矿工程 • 上一篇    下一篇

倾斜管实验的膏体流变特性规律研究

张友志1,2,薛振林1,2,刘志义1,2,孙光华1,2   

  1. 1.华北理工大学矿业工程学院,河北 唐山 063210;2.河北省矿业开发与安全技术重点实验室,河北 唐山 063210
  • 出版日期:2018-03-15 发布日期:2018-03-20
  • 基金资助:

    基金项目:华北理工大学青年科学研究基金项目(编号:Z201617),河北省自然科学基金项目(编号:E2016209277)。

Research on Rheological Behavior of Paste Based on Inclined Pipeline Test

Zhang Youzhi1,2,Xue Zhenlin1,2,Liu Zhiyi1,2,Sun Guanghua1,2   

  1. 1.College of Mining Engineering,North China University of Science and Technology,Tangshan 063210,China;2.Hebei Province Key Laboratory of Mining Development and Safety Technology,Tangshan 063210,China
  • Online:2018-03-15 Published:2018-03-20

摘要: 针对膏体流变特性难以真实测量的现象,自制一套能够有效还原工业现场的倾斜管道实验装置,对膏体流变特性参数进行测量,运用通径分析法探究膏体浓度、灰砂比对流变特性的影响规律。结果表明:膏体浓度、灰砂比对膏体流变参数的影响均为正相关,其中,浓度对屈服应力的影响水平比灰砂比对其影响水平大一个数量级,当灰砂比接近1∶25时,灰砂比的增大与减小并不能引起屈服应力明显的单调递增递减现象;浓度对塑性黏度的影响水平比灰砂比对其影响水平大,但在同一个数量级,膏体浓度较低时,会产生浓度低黏度大的现象。

关键词: 膏体充填, 倾斜管道, 流变特性, 通径分析

Abstract: Aiming at the phenomenon that the rheological behavior of paste is difficult to be measured factually,an inclined pipeline test device which can rebuild the industrial sites effectively was manufactured to survey the rheological parameters of the paste.The influencing law of paste concentration and cement-sand ratio on the rheological properties of the pastes was investigated by path analysis method.The result showed that:the influence of paste concentration and cement-sand ratio on the rheological parameters of the paste is positive correlation;The influence of concentration on yield stress is an order of magnitude larger than that of cement-sand ratio;When the cement-sand ratio approaches to 1∶25,the increase and decrease of cement-sand ratio does not cause obvious monotonically increasing and decreasing phenomenon of yield stress;The influence of concentration on plastic viscosity is higher than that of cement-sand ratio,under the same order of magnitude;When the paste concentration is low,a phenomenon of low concentration with large viscosity will be generated.

Key words: Paste backfill, Inclined pipeline, Rheological behavior, Path analysis