电弧炉烟尘湿法提锌研究

金属矿山 ›› 2011, Vol. 40 ›› Issue (02): 153-156.

电弧炉烟尘湿法提锌研究

罗伟^1,2，徐政^1,2，张寒霜^1,2，杨丽梅^1,2，李岩^1,2

1.北京有色金属研究总院；2.生物冶金国家工程试验室

出版日期:2011-02-10 发布日期:2011-02-15
基金资助:
国家重点基础研究发展计划（973计划）项目（编号：2010CB630906），国家高技术研究发展计划（863计划）项目（编号：2007AA060903）

Research on Zinc Extraction with Electric Arc Furnace Dust

Luo Wei^1,2，Xu Zheng^1,2，Zhang Hanshuang^1,2，Yang Limei^1,2，Li Yan^1,2

1.General Research Institute for Nonferrous Metals；2.National Engineering Laboratory of Biohydrometallurgy

Online:2011-02-10 Published:2011-02-15

摘要/Abstract

摘要： 江苏苏钢集团电弧炉炼钢烟尘含锌15.4%，并主要分布在铁酸锌中。对该炼钢烟尘进行浸出试验，结果表明：以氢氧化钠为浸出剂进行碱性浸出时，锌的浸出率仅为34.0%；以硫酸为浸出剂进行酸性浸出时，在搅拌转速为420 r/min，硫酸浓度为200 g/L，液固比为10∶1，反应温度为90 ℃，浸出时间为2 h的条件下，锌的浸出率达到98.7%。

关键词: 电弧炉烟尘, 碱性浸出, 酸性浸出, 锌浸出率

Abstract: The electric arc furnace dust in Jiangsu Sugang Group contains Zn content of 15.4% and is mainly embedded in zinc ferrite. Results of the leaching tests on this dust showed that only 34.0% of zinc was extracted when sodium hydroxide as lixiviant in alkaline leaching. And about 98.7% of zinc was leached out with sulphuric acid as lixiviant under the experimental conditions of stirring at 420 r/min, 200 g/L of H2SO4, reaction temperature 90 ℃, liquid to solid ratio 10∶1 and reaction time 2 h.

Key words: Electric arc furnace dust, Alkaline leaching, Acid leaching, Zinc leaching rate

罗伟, 徐政, 张寒霜, 杨丽梅, 李岩. 电弧炉烟尘湿法提锌研究[J]. 金属矿山, 2011, 40(02): 153-156.

LUO Wei, XU Zheng, ZHANG Han-Shuang, YANG Li-Mei, LI Yan. Research on Zinc Extraction with Electric Arc Furnace Dust[J]. Metal Mine, 2011, 40(02): 153-156.

扫码分享