矿山酸性废水处理生物转盘反应器启动及工艺特性研究

金属矿山 ›› 2009, Vol. 39 ›› Issue (08): 153-157.

矿山酸性废水处理生物转盘反应器启动及工艺特性研究

王英刚¹，孙丽娜¹，魏德洲²

1.沈阳大学；2.东北大学

出版日期:2009-08-17 发布日期:2011-04-26
基金资助:
国家重大水专项资助项目(编号：2008ZX07208-003)，辽宁省科技厅资助项目（编号：2008101）。

Research on the Start-up and Process Properties of Rotating Biological Contactor for Acid mine Drainage Treatment

Wang Yinggang¹，Sun Lina¹，Wei Dezhou²

1.Shenyang University；2.Northeastern University

Online:2009-08-17 Published:2011-04-26

摘要/Abstract

摘要： 生物转盘反应器是一种高效率的微生物固定化装置，很适合处理水量适中的矿山酸性废水。研究了生物转盘反应器启动阶段的工艺条件。试验结果表明：以10%接种量接种，连续6次培养后，可完成反应器的启动；伴随着多次反复培养挂膜进程，Fe²⁺氧化周期不断缩短，由最初的100 h降低到70 h，同时生物膜对Fe²⁺的氧化能力不断趋于稳定。考察了反应器在稳定阶段时，水力停留时间、转盘转速和入口浓度对Fe²⁺氧化率的影响。结果表明，在本试验条件下，最佳水力停留时间为4 h，合理转盘转速为7 r/min。

关键词: 固定化氧化亚铁硫杆菌, 生物转盘反应器, 矿山酸性废水

Abstract: The rotating biological contactor is a high efficient immobilized device for microorganism which is suitable for treating the acid mine drainage.The process conditions of the start-up and stabilizing stage of rotating biological contactor are studied.The test result shows that the start-up of reactor can be affected by six consecutive cultivations with 10% inoculation amount.With the repeated biofilm forming process, the cycle of Fe²⁺ oxidation is shortened continuously, from the initial 100 h to 70 h, and meanwhile, the biofilm's capacity of Fe²⁺ oxidation tends to become stable.The impact of the hydraulic retention time, rotating speed and inlet concentration on Fe2+ oxidation rate in a stable treatment process for acid mine drainage was investigated.The results show that are the best, the 4 h hydraulic retention time and the 7 r/min rational rotating speed.

Key words: Immobilized Acidithiobacillus ferrooxidans, Rotating biological contactor, Acid mine drainage

王英刚, 孙丽娜, 魏德洲. 矿山酸性废水处理生物转盘反应器启动及工艺特性研究[J]. 金属矿山, 2009, 39(08): 153-157.

WANG Ying-Gang, SUN Li-Na, WEI De-Zhou. Research on the Start-up and Process Properties of Rotating Biological Contactor for Acid mine Drainage Treatment[J]. Metal Mine, 2009, 39(08): 153-157.

[1]	沈青峰. 矿山酸性废水中和处理工艺优化研究[J]. 金属矿山, 2019, 48(03): 189-193.
[2]	陈月芳, 张国华, 高琨, 季振, 安丹凤. 固定化生物活性炭技术处理模拟铅锌矿山酸性废水[J]. 金属矿山, 2014, 43(06): 171-176.
[3]	余水静, 彭艳平. 硫酸盐还原菌处理矿山酸性废水的试验研究[J]. 金属矿山, 2011, 40(1): 124-127.
[4]	何孝磊, 程一松, 何丽. HDS工艺处理某矿山酸性废水试验研究[J]. 金属矿山, 2010, 39(1): 147-150+174.
[5]	杨群, 宁平, 陈芳媛, 赵天亮. 矿山酸性废水治理技术现状及进展[J]. 金属矿山, 2009, 39(1): 131-134.
[6]	赵玲, 王荣锌, 李官, 陈明. 矿山酸性废水处理及源头控制技术展望[J]. 金属矿山, 2009, 39(07): 131-135.
[7]	白怀良, 钟铁, 高铜生. 矿山酸性废水治理HDS工艺技术研究[J]. 金属矿山, 2008, 38(9): 143-145+151.